Preparation of Lanthanum-doped TiO2 Film and Its Application for Gaseous Toluene Removal

doi:10.3724/SP.J.1077.2010.00928

Abstract

Abstract:

Visible light response lanthanum-doped TiO₂ film was prepared by Sol–Gel method using Ti(OBu)₄ and La(NO)₃·6H₂O as raw materials. XPS, FTIR, XRD, N2(77K) adsorption, SEM and DRS were used for catalyst characterization. Gaseous toluene removal was used for photocatalytic activity test. The results show that La dopant can induce visible light activity. The sample of 2.8-La/TiO₂-500 exhibites the highest activity, which can remove toluene of initial concentration 6110.18mg/m³ completely within 60min. La³⁺ disperses onto TiO₂as the form of La₂O₃and partly as the form of Ti-O-La bond. La dopant can inhibit phase transformation, enhance phase transformation temperature and is also beneficial to gain smaller particle size and large surface area of TiO₂. Compared with pure TiO₂film, La dopant can also inhibit the generation of air-pores and the surface of La/TiO₂ film is more dense and smooth. Electrons transfer of f level of La and the destortion of TiO₂ lattice is the main reason for the enhancement of visible-light activity.

Key words: visible light, La doped, TiO₂, film, toluene

CLC Number:

TM23

SUN Jian, LIU Shou-Xin. Preparation of Lanthanum-doped TiO₂ Film and Its Application for Gaseous Toluene Removal[J]. Journal of Inorganic Materials, 2010, 25(9): 928-934.

References

[1] 孙剑, 李晓辉, 刘守新. 吸附—光催化联用去除室内VOCs研究进展. 化学进展, 2009, 21(10): 2067-2076.
[2] Jutta B, Erich J, Türkan K, et al. Performance of two different types of passive samplers for the GC/ECD-FID determination of environmental VOC levels in air. Fresen. J. Anal. Chem., 1999, 363(4): 399-403.
[3] Cornejo J J, Munoz F G, Ma C Y, et al. Studies on the decontemination of air by plant. Ecotoxicology, 1999, 8(4): 312-320.
[4] Jirapat A, Puangrat K, Supapan S. Visible light absorption ability and photocatalytic oxidation activity of various interstitial N-doped TiO2 prepared from different nitrogen dopants. Journal of Hazardous Materials, 2009, 168(1): 253-261.
[5] 李辉, 王金淑, 李洪义, 等(LI Hui, et al). 氮硫掺杂介孔TiO2薄膜结构及其光催化性能. 无机材料学报(Journal of Inorganic Materials), 2009, 24(5): 909-914.
[6] Colón G, Hidalgo M C, Macías M, et al. Enhancement of TiO2/C photocatalytic activity by sulfate promotion. Applied Catalysis A: General, 2004, 259(2): 235-243.
[7] Xie Y, Zhao X J, Li Y Z. CTAB-assisted synthesis of mesoporous F–N-codoped TiO2 powders with high visible-light-driven catalytic activity and adsorption capacity. Journal of Solid State Chemistry, 2008, 181(8): 1936-1942.
[8] 陈其凤, 姜东, 徐耀, 等(CHEN Qi-Feng, et al). 溶胶-凝胶-水热法制备Ce-Si/TiO2及其可见光催化性能. 物理化学学报(Acta Phys-Chim. Sin.), 2009, 25(4): 617-623.
[9] Chan Chih-Chieh, Chang Chung-Chieh, Hsu Wen-Chia. Photocatalytic activities of Pd-loaded mesoporous TiO2 thin films. Chemical Engineering Journal, 2009, 152(2/3): 492-497.
[10] 刘守新, 陈孝云, 李晓辉(LIU Shou-Xin , et al). N掺杂对TiO2形态结构及光催化活性的影响. 无机化学学报(Chinese J. Inorg. Chem.), 2008, 24(2): 253-259.
[11] Jing L Q, Sun X J, Xin B F, et al. The preparation and characterization of La doped TiO2 nanoparticles and their photo-
catalytic activity. J. Solid State Chem., 2004, 177(10): 3375-3382.
[12] Wu X H, Ding X B, Qin W, et al. Enhanced photo-catalytic activity of TiO2 films with doped La prepared by micro-plasma oxidation method. J. Hazard. Mater. B, 2006, 137(1): 192-197.
[13] Yuan Sh, Sheng Q R, Zhang J L, et al. Synthesis of La3+ doped mesoporous titania with highly crystallized walls. Microporous Mesoporous Mater., 2005, 79(1/2/3): 93-99.
[14] Atribak I, Such-Basanez I, Bueno-Lopez A, et al. Catalytic activity of La-modified TiO2 for soot oxidation by O2. Catal. Commun., 2007, 8(3): 478-482.
[15] Masashi I, Li J G, Norio K. Phase formation and luminescence properties in Eu3+-doped TiO2 nanoparticles prepared by thermal plasma pyrolysis of aqueous solutions. Thin Solid Films, 2008, 516(19): 6640-6644.
[16] Setiawati E, Kawano K. Stabilization of anatase phase in the rare earth; Eu and Sm ion doped nanoparticle TiO2. Journal of Alloys and Compounds, 2008, 451(1/2): 293-296.
[17] Hwang D W, Lee J S, Li W, et al. Electronic band structure and photocatalytic activity of Ln2Ti2O7 (Ln = La, Pr, Nd). J. Phys. Chem. B, 2003,107(21): 4963-4970.
[18] Zhang Y H, Zhang H S, Xu Y X, et al. Europium doped nanocrystal-
line titanium dioxide: preparation,phase transformation and photo-
catalytic properties. J. Mater. Chem., 2003, 13(1): 2261-2265.
[19] Liu H, Li X Z. An alternative approach to ascertain the rate-determining steps of TiO2 photoelectrocatalytic reaction by electrochemical impedance spectroscopy. J. Phys. Chem. B, 2003, 107(34): 8988-8996.
[20] Wang C, Zhang X H, Liu H, et al. Reaction kinetics of photocatalytic degradation of sulfosalicylic acid using TiO2 microspheres. J. Hazard. Mater., 2009, 163(2/3): 1101-1106.
[21] Li X Z, Liu H. Photocatalytic oxidation using a new catalyst-TiO2 microsphere for water and wastewater treatment. Environ. Sci. Technol., 2003, 37(17): 3989-3994.
[22] Kamat P V. photochemical and photocatalytic aspects of metal nanoparticles. J. Phys. Chem. B, 2002, 106(32): 7729-7744.
[23] Bae E, Choi W. Highly enhanced photoreductive degradation of perchlorinated compounds on dye-sensitized metal/TiO2 under visible light. Environ. Sci. Technol., 2003, 37(1): 147-152.
[24] Fang J, Bi X, Si D, et al. Spectroscopic studies of interfacial structures of CeO2–TiO2 mixed oxides. Appl. Surf. Sci., 2007, 253(22): 8952-8961.
[25] 刘正峰. TiO2/ACF复合材料的溶胶-凝胶法制备及其对苯的去除性能研究. 哈尔滨: 东北林业大学硕士论文, 2008.
[26] 李晓辉, 刘守新(LI Xiao-Hui, et al). N、F共掺杂TiO2可见光响应光催化剂的酸催化水解法制备及表征. 物理化学学报(Acta Phys-Chim. Sin.), 2008, 24(11): 2019-2024.
[27] Yamaki T, Umebayashi T, Sumita T, et al. Fluorine-doping in titanium dioxide by ion implantation technique. Nucl. Instr. Meth. Phys. Res. B, 2003, 206(1): 254-258.
[28] Suzuki S, Ishii T, Sagawa T. X-Ray photoemission spectra of 4d and 3d electrons in lanthanum- and cerium-halides. J. Phys. Soc. Jpn., 1974, 37(5): 1334-1340.
[29] Ao C H, Lee S C. Enhancement effect of TiO2 immobilized on activated carbon filter for the photodegradation of pollutants at typi-cal indoor air level. Appl. Catal. B: Environ., 2003, 44(3): 191-205.
[30] Soler-Illia G, Louis A, Sanchez C. Synthesis and characterization of mesostruetured titania-based materials through evaporation-induced self-assembly. Chem. Mater., 2002, 14(2): 750-759.
[31] 尹荔松, 谭敏, 陈永平, 等. La掺杂对纳米TiO2薄膜晶体结构和光催化性能的影响. 中南大学学报, 2008, 39(4): 665-671.
[32] 方舒玫, 欧延, 林敬东, 等. La2O3掺杂低温合成介孔锐钛矿相二氧化钛. 中国稀土学报, 2006(S2): 32-36.
[33] Ebitani K, Hirano Y, Morikawa A. Rare-earth ions as heterogene-ous photocatalysts for the decomposition of dinitrogen monoxide. J. Catal., 1995, 157(1): 262-265.
[34] Li F, Li X, Hou M. Photocatalytic degradation of 2-mercap-tobenzothiazole in aqueous La3+–TiO2 suspension for odor control. Appl. Catal. B: Environ., 2004, 48(3): 185-194.

Preparation of Lanthanum-doped TiO₂ Film and Its Application for Gaseous Toluene Removal

PDF (PC)

Knowledge

Cited

Abstract

Cite this article

share this article

References

Related Articles 15

Recommended Articles

Metrics

Comments

[1]	MA Binbin, ZHONG Wanling, HAN Jian, CHEN Liangyu, SUN Jingjing, LEI Caixia. ZIF-8/TiO₂ Composite Mesocrystals: Preparation and Photocatalytic Activity [J]. Journal of Inorganic Materials, 2024, 39(8): 937-944.
[2]	ZHAO Zhihan, GUO Peng, WEI Jing, CUI Li, LIU Shanze, ZHANG Wenlong, CHEN Rende, WANG Aiying. Ti Doped Diamond Like Carbon Films: Piezoresistive Properties and Carrier Transport Behavior [J]. Journal of Inorganic Materials, 2024, 39(8): 879-886.
[3]	ZHANG Hui, XU Zhipeng, ZHU Congtan, GUO Xueyi, YANG Ying. Progress on Large-area Organic-inorganic Hybrid Perovskite Films and Its Photovoltaic Application [J]. Journal of Inorganic Materials, 2024, 39(5): 457-466.
[4]	SHEN Bin, ZHANG Xu, XIONG Huai, LI Haiyuan, XIE Xinglong. Preparation and Optical Properties of Sol-Gel SiO₂ Antireflective Films [J]. Journal of Inorganic Materials, 2024, 39(5): 525-530.
[5]	BAO Ke, LI Xijun. Chemical Vapor Deposition of Vanadium Dioxide for Thermochromic Smart Window Applications [J]. Journal of Inorganic Materials, 2024, 39(3): 233-258.
[6]	YANG Zhiliang, YANG Ao, LIU Peng, CHEN Liangxian, AN Kang, WEI Junjun, LIU Jinlong, WU Lishu, LI Chengming. Preparation of 3-inch Diamond Film on Silicon Substrate for Thermal Management [J]. Journal of Inorganic Materials, 2024, 39(3): 283-290.
[7]	LIU Song, ZHANG Faqiang, LUO Jin, LIU Zhifu. 0.9BaTiO₃-0.1Bi(Mg_1/2Ti_1/2)O₃ Ferroelectric Thin Films: Preparation and Energy Storage [J]. Journal of Inorganic Materials, 2024, 39(3): 291-298.
[8]	XU Xiangming, Husam N ALSHAREEF. Perspective of MXetronics [J]. Journal of Inorganic Materials, 2024, 39(2): 171-178.
[9]	REN Guanyuan, LI Yiguan, DING Donghai, LIANG Ruihong, ZHOU Zhiyong. CaBi₂Nb₂O₉ Ferroelectric Thin Films: Modulation of Growth Orientation and Properties [J]. Journal of Inorganic Materials, 2024, 39(11): 1228-1234.
[10]	ZHANG Zhe, SUN Tingting, WANG Lianjun, JIANG Wan. Flexible Thermoelectric Films with Different Ag₂Se Dimensions: Performance Optimization and Device Integration [J]. Journal of Inorganic Materials, 2024, 39(11): 1221-1227.
[11]	DAI Le, LIU Yang, GAO Xuan, WANG Shuhao, SONG Yating, TANG Mingmeng, DMITRY V Karpinsky, LIU Lisha, WANG Yaojin. Self-polarization Achieved by Compositionally Gradient Doping in BiFeO₃ Thin Films [J]. Journal of Inorganic Materials, 2024, 39(1): 99-106.
[12]	HU Ying, LI Ziqing, FANG Xiaosheng. Solution-prepared AgBi₂I₇ Thin Films and Their Photodetecting Properties [J]. Journal of Inorganic Materials, 2023, 38(9): 1055-1061.
[13]	WANG Donghai, LI Dongzhen, XU Jun. An Important Breakthrough in the Technology of Sapphire Plate with Large Size Grown by the Edge-defined Film-fed Growth Method [J]. Journal of Inorganic Materials, 2023, 38(3): 363-364.
[14]	CHEN Mingyue, YAN Zhichao, CHEN Jing, LI Minjuan, LIU Zhiyong, CAI Chuanbing. YBa₂Cu₃O_7-_δ Thin Film: Preparation by BaCl₂/BaF₂-MOD Method and Superconducting Property [J]. Journal of Inorganic Materials, 2023, 38(2): 199-204.
[15]	XIE Bing, CAI Jinxia, WANG Tongtong, LIU Zhiyong, JIANG Shenglin, ZHANG Haibo. Research Progress of Polymer-based Multilayer Composite Dielectrics with High Energy Storage Density [J]. Journal of Inorganic Materials, 2023, 38(2): 137-147.