(1-x)(Mg0.9Co0.1)TiO3-x(Ca0.61La0.26)TiO3陶瓷的微波介电性能

doi:10.3724/SP.J.1077.2011.11060

无机材料学报 ›› 2011, Vol. 26 ›› Issue (6): 664-668.DOI: 10.3724/SP.J.1077.2011.11060 CSTR: 32189.14.SP.J.1077.2011.11060

(1-x)(Mg_0.9Co_0.1)TiO₃-x(Ca_0.61La_0.26)TiO₃陶瓷的微波介电性能

刘昊, 沈春英, 卢正东, 丘泰

(南京工业大学材料科学与工程学院, 南京210009)

收稿日期:2010-01-18 修回日期:2011-03-02 出版日期:2011-06-20 网络出版日期:2011-06-07

Microwave Dielectric Properties of the (1-x)(Mg_0.9Co_0.1)TiO₃-x(Ca_0.61La_0.26)TiO₃ Ceramics

LIU Hao, SHEN Chun-Ying, LU Zheng-Dong, QIU Tai

(College of Materials Science and Engineering, Nanjing University of Technology, Nanjing 210009, China)

Received:2010-01-18 Revised:2011-03-02 Published:2011-06-20 Online:2011-06-07
About author:LIU Hao(1987-), male, candidate of master. E-mail: kyleliu@sohu.com

摘要/Abstract

摘要： 研究了(1-x)(Mg_0.9Co_0.1)TiO₃-x(Ca_0.61La_0.26)TiO₃(MCT-CLT)体系陶瓷的微波介电性能. 目的是通过(Ca_0.61La_0.26)TiO₃ (CLT)协调(Mg_0.9Co_0.1)TiO₃(MCT)陶瓷的谐振频率温度系数. 实验发现, 烧结温度和陶瓷组成对微波介电性能影响显著, 当烧结温度为1300℃时, 可以获得良好的致密度, 当烧结温度超过1300℃时, 陶瓷致密度和介电性能下降. 此外, 随着CLT含量的增加, 材料的介电常数增大, 品质因数减小. 当CLT含量为13%, 烧结温度为1300℃, 保温2h, (MCCLT)陶瓷具有优良微波介电性能, ε_r =22.4, Q×f =35000 GHz, τ_f = -8.7×10^-6/℃, 从而达到实用要求.

关键词: (1-x)(Mg_0.9Co_0.1)TiO₃-x(Ca_0.61La_0.26)TiO₃陶瓷, 微波介质陶瓷, 介电常数, 品质因数, 谐振频率温度系数

Abstract: The microwave dielectric properties of the (1-x)(Mg_0.9Co_0.1)TiO₃-x(Ca_0.61La_0.26)TiO₃(MCT-CLT) ceramics were investigated. The system was prepared using a conventional solid-state ceramic route. The objective of the present work is to compensate for the negative temperature coefficient of resonant frequency (τ_f) of (Mg_0.9Co_0.1)TiO₃ (MCT) by the addition of (Ca_0.61La_0.26)TiO₃ (CLT). The microwave dielectric properties are strongly correlated with the sintering temperature and the composition. Very dense MCT-CLT ceramics were prepared by sintering at 1300℃. When the ceramics were sintered at temperatures above 1300℃, the bulk density decreased and the dielectric properties deteriorated. With the increasing of x, the relative dielectric constant (ε_r) of the ceramics increases and the product of quality factor and resonant frequency (Q×f) decreases. For practical application, 0.87(Mg_0.9Co_0.1)TiO₃- 0.13(Ca_0.61La_0.26)TiO₃ (87MCT-13CLT) ceramics sintered at 1300℃ with a dielectric constant ε_r=22.4, a Q×f value of 35000 GHz and a temperature coefficient of resonance frequency (τ_f) of -8.7×10^-6/℃ was proposed in this paper.

Key words: (1-x)(Mg_0.9Co_0.1)TiO₃-x(Ca_0.61La_0.26)TiO₃ ceramics, microwave dielectric ceramics, dielectric constant, quality factor, temperature stable resonant frequency

中图分类号:

TQ174

刘昊, 沈春英, 卢正东, 丘泰. (1-x)(Mg_0.9Co_0.1)TiO₃-x(Ca_0.61La_0.26)TiO₃陶瓷的微波介电性能[J]. 无机材料学报, 2011, 26(6): 664-668.

LIU Hao, SHEN Chun-Ying, LU Zheng-Dong, QIU Tai. Microwave Dielectric Properties of the (1-x)(Mg_0.9Co_0.1)TiO₃-x(Ca_0.61La_0.26)TiO₃ Ceramics[J]. Journal of Inorganic Materials, 2011, 26(6): 664-668.

参考文献

[1] Long S A, Mcallister M W, Shen L C. The resonant cylindrical dielectric cavity antenna. IEEE Trans., 1983, 31(3): 406-412.

[2] Wersing W. Microwave ceramics for resonators and filters. Curr.Opin. Solid State. Mater. Sci., 1996, 1(5): 715-731.

[3] Huang C L, Weng M H. Improved high q value of MgTiO3-CaTiO3 microwave dielectric ceramics at low sintering temperature. Mater. Res. Bull., 2001, 36(15): 2741-2750.

[4] Cho W W, Kakimoto K, Ohsato H. High-Q microwave dielectric SrTiO3-doped MgTiO3 materials with near-zero temperature coefficient of resonant frequency. Jpn. J. Appl. Phys., 2004, 43(9A): 6221-6224.

[5] Lu Z D, Shen C Y, Qiu T. Studies on microwave dielectric properties of (Mg1-xCox)TiO3 system ceramics. Bulletin of the Chinese Ceramics Society, 2010, 29(2): 284-287.

[6] Zhao L, Shen C Y, Qiu T. Studies on the (1-x)Mg0.7Zn0.3TiO3-xCa0.61La0.26TiO3 microwave dielectric ceramics system. Journal of Inorganic Materials, 2011, 26(2): 219-224.

[7] Hakki B W, Coleman P D. A dielectric resonator method of measuring inductive capacities in the millimeter range. Microwave Theory Technol. 1960, 8(4): 402-410.

[8] Kobayshi Y, Katoh M. Microwave measurement of dielectric properties of low-loss materials by the dielectric rod resonator method. IEEE Trans. Microwave Theory Technol., 1985, 33(7): 586-592.

[9] German R M. Liquid Phase Sintering. Plenum: New York, 1987: 127-151.

[10] Huang C L, Chung L P, Jui F H, et al. Microwave dielectric properties and mixture behavior of (Mg0.95Co0.05)TiO3-Ca0.6La0.8/3TiO3 ceramic system. J. Alloys Compd., 2008, 461(1): 521-526.

[11] Huang C L, Pan C L, Hsu J F. Dielectric properties of (1-x)(Mg0.95Co0.05)TiO3-xCaTiO3 ceramic system at microwave frequency. Mater. Res. Bull., 2002, 37(15): 2483-2490.

[12] Huang C L, Chen Y B, Lo C W. New dielectric material system of La(Mg1/2Ti1/2)O3-CaTiO3 at microwave frequencies. Jpn. J. Appl. Phys., 2005, 44: 3147-3150.

[1]	何思哲, 王俊舟, 张勇, 费嘉维, 吴爱民, 陈意峰, 李强, 周晟, 黄昊. 高频低损耗的Fe/亚微米FeNi软磁复合材料[J]. 无机材料学报, 2024, 39(8): 871-878.
[2]	李俊生, 曾良, 刘荣军, 王衍飞, 万帆, 李端. 锶钽氧氮化物功能陶瓷的高效合成、致密化及介电性能研究[J]. 无机材料学报, 2023, 38(8): 885-892.
[3]	谢兵, 蔡金峡, 王铜铜, 刘智勇, 姜胜林, 张海波. 高储能密度聚合物基多层复合电介质的研究进展[J]. 无机材料学报, 2023, 38(2): 137-147.
[4]	李汪国, 刘佃光, 王珂玮, 马百胜, 刘金铃. 闪烧合成高熵氧化物陶瓷(MgCoNiCuZn)O的性能[J]. 无机材料学报, 2022, 37(12): 1289-1294.
[5]	梁汉琴, 尹金伟, 左开慧, 夏咏锋, 姚冬旭, 曾宇平. 添加BaTiO₃的热压烧结Si₃N₄陶瓷的力学和介电性能[J]. 无机材料学报, 2021, 36(5): 535-540.
[6]	宋建民, 代秀红, 梁杰通, 赵磊, 周阳, 葛大勇, 孟旭东, 刘保亭. 偏轴磁控溅射法外延BiFeO₃薄膜的介电性能与阻变效应[J]. 无机材料学报, 2018, 33(9): 1017-1021.
[7]	王璐, 孔文杰, 罗行, 周学凡, 周科朝, 张斗. BaTiO₃纳米线的制备及其复合物介电和储能性能研究[J]. 无机材料学报, 2018, 33(10): 1059-1064.
[8]	黄栋, 吴颖, 苗纪远, 刘志甫, 李永祥. (Nb, Al)共掺BaTiO₃陶瓷的巨介电及介电弛豫现象[J]. 无机材料学报, 2017, 32(2): 219-224.
[9]	李海涛, 李谦, 闫焉服, 许荣辉. ZnO掺杂对Ca_0.25(Li_0.43Sm_0.57)_0.75TiO₃陶瓷烧结性能和微波介电性能的影响[J]. 无机材料学报, 2015, 30(4): 369-373.
[10]	谢慧, 袁淑娟, 康保娟, 鲁波, 曹世勋, 张金仓 . Ho_0.5Pr_0.5FeO₃的磁性与巨磁介电效应[J]. 无机材料学报, 2014, 29(1): 77-80.
[11]	王莉, 罗发, 刘莉, 周万城, 朱冬梅. CB/PBO复合材料制备及吸波性能研究[J]. 无机材料学报, 2013, 28(12): 1333-1337.
[12]	范跃农, 冯则坤, 陈中艳, 龚荣洲. 电感器用Ni-Cu-Zn铁氧体薄膜的设计与性能研究[J]. 无机材料学报, 2012, 27(4): 375-378.
[13]	刘林, 方有维, 邓新峰, 庄文东, 唐斌, 张树人. (Ba_1-xSr_x)La₄Ti₄O₁₅(x=0.8~0.95)陶瓷的微结构及微波介电性能研究[J]. 无机材料学报, 2012, 27(3): 281-284.
[14]	姚晓刚, 林慧兴, 姜少虎, 陈玮, 罗澜. Al₂O₃掺杂对Ba₄Sm_9.33Ti₁₈O₅₄陶瓷显微结构和介电性能的影响[J]. 无机材料学报, 2012, 27(12): 1266-1270.
[15]	谢炜, 程海峰, 匡加才, 陈朝辉, 楚增勇, 龙春光. 热处理升温速率对中空多孔炭纤维介电常数的影响[J]. 无机材料学报, 2011, 26(9): 939-943.

(1-x)(Mg_0.9Co_0.1)TiO₃-x(Ca_0.61La_0.26)TiO₃陶瓷的微波介电性能

Microwave Dielectric Properties of the (1-x)(Mg_0.9Co_0.1)TiO₃-x(Ca_0.61La_0.26)TiO₃ Ceramics

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价