无机材料学报

• 研究论文 • 上一篇    下一篇

[100]取向Al-Ti共掺杂ZnO薄膜的制备与光电性能研究

江民红1, 2, 刘心宇1, 2   

  1. 1. 桂林电子科技大学 信息材料科学与工程系, 桂林 541004; 2. 中南大学 材料科学与工程学院, 长沙 410083
  • 收稿日期:2008-01-03 修回日期:2008-03-07 出版日期:2008-11-20 网络出版日期:2008-11-20

Preparation and Photoelectric Properties of Al-Ti Codoped ZnO Thin Films with [100] Preferred Orientation

JIANG Min-Hong1,2, LIU Xin-Yu1,2   

  1. 1. Department of Information Material Science and Engineering, Guilin University of Electronic Technology, Guilin 541004, China; 2. College of Material Science and Engineering, Central South University, Changsha 410083, China
  • Received:2008-01-03 Revised:2008-03-07 Published:2008-11-20 Online:2008-11-20

摘要: 采用常压固相烧结法制备了Al-Ti共掺ZnO靶材, 采用射频磁控溅射技术及真空退火工艺, 在普通玻璃衬底上制备了具有[100]取向Al-Ti共掺杂ZnO薄膜(ZATO). 采用X射线衍射(XRD)、扫描电子显微镜(SEM)对ZATO薄膜的生长机理、显微结构、形貌进行了测试分析, 用四探针测试仪、紫外-可见分光光度计及荧光光谱仪对ZATO薄膜的光电性能进行了测试分析. 结果表明, ZATO薄膜经500℃保温3h退火后, 择优取向由(002)向(100)方向转变; 此时, 衍射谱上还观察到超点阵衍射线条. [100]取向ZATO薄膜的光学带隙从退火前的3.29降至2.86, 平均可见光透过率从90%降至70%, 表现为一般的透过性; 而电阻率则从1.89×10-2Ω·cm降至1.25×10-3Ω·cm, 呈现较好的导电性. 薄膜中均出现了380nm附近的带边发射(NBE)峰以及410、564nm的深能级发射峰, 且经500℃保温3h退火后, 这些峰的位置并未改变, 但峰强均明显减弱. 对上述实验机理进行了分析讨论.

关键词: ZnO薄膜, Ti-Al共掺杂, [100]取向, 光电性能

Abstract: Al-Ti codoped ZnO (ZATO) films with (100) preferred orientation were grown on the glass substrates at room temperature by RF magnetron sputtering. The Al-Ti codoped ZnO ceramic targets used for sputtering were prepared by the conventional solid-state sintering process. The growth mechanism, microstructures and surface figures of ZATO films were investigated by X-ray diffraction (XRD) and scanning electronic microscope (SEM), and its optical and electrical properties were respectively measured using a four-point probe technique and UV-756 spectrophotometer at room temperature. After the ZATO films annealed at 500℃ for 3h, the preferred growth orientation of the films changes from (002) to (100) orientation, and the optic band gap reduces from 3.29eV to 2.86eV, and the average transmittance reduces from 90% to 70%, but the room-temperature resistivity reduces from 1.89×10-2Ω·cm to 1.25×10-3 Ω·cm. And at the same time, there is a super-lattice diffraction ray in the XRD patterns of annealed the ZATO films. The photoluminescence (PL) spectra confirm that there exhibit the near-band-edge (NBE) emission peaks at 380nm, and 410nm, 564nm PL peaks of all the films. After the films are annealed at 500℃ for 3h, the strength of these PL peaks drops, but its positions change little. The above experimental mechanisms were discussed.

Key words: ZnO thin films, Ti-Al codopant, [100] orientation, photoelectric properties

中图分类号: