高级检索
无机材料学报

无机材料学报

• 研究论文 • 上一篇    下一篇

微混合沉淀技术制备纳米TiO2颗粒

陈桂光; 骆广生; 杨雪瑞; 孙怡文; 汪家鼎   

  1. 化学工程联合国家重点实验室（清华大学） 北京 100084
  • 收稿日期:2003-09-08 修回日期:2003-10-27 出版日期:2004-09-20 网络出版日期:2004-09-20

Preparation of Ultra-fine TiO2 Particles Using Micro-Mixing Precipitation Technology

CHEN Gui-Guang; LUO Guang-Sheng; YANG Xue-Rui; SUN Yi-Wen; WANG Jia-Ding   

  1. The Satate Key Laboratory of Chemical Engineering; Department of Chemical Engineering; Tsinghua University; Beijing 100084; China
  • Received:2003-09-08 Revised:2003-10-27 Published:2004-09-20 Online:2004-09-20

PDF (PC)

1074

摘要： 以Ti(SO4)2为分散相,NH4HCO3为连续相,通过膜分散实现液液的微混合沉淀,从而制备纳米TiO2晶体颗粒.分别研究了两种反应物浓度和流量对制备的TiO2颗粒的影响,并利用XRD和TEM分别对所得颗粒的晶型和形态进行了表征.实验结果表明,制得的颗粒具有球形度高,粒径小,分布范围窄,且为锐钛矿结构的特点.TiO2的晶粒粒度和颗粒粒径随Ti(SO4)2和NH4HCO3浓度的上升,先有所上升再下降;随Ti(SO4)2流量的上升而下降;随NH4HCO3流量的上升而上升.微混合沉淀技术是一种很好的控制颗粒粒径、且连续化沉淀制备TiO2超细颗粒的新方法.

关键词: 微混合沉淀, TiO2, 超细

Abstract: A method of micro-mixing-precipitation technology was developed from membrane dispersion technology to prepare
ultra-fine TiO2 particles. Titanic sulfate was selected as the dispersed phase, and ammonium acid carbonate as the continuous phase. The influences of
the reactant concentrations and two-phase flow rate were investigated. The crystal structure and crystal dimension of the particles were analyzed by
XRD, morphology, particle size and size distribution by TEM. The results showed that the spheric TiO2 nano-particles with small size and narrow
size distribution could be prepared with the method. The crystal dimension and the particle size of the TiO2 particles were increased with the
increasing of reactant concentrations at first, then decreased. They also were decreased with the increasing of the flow rate of Ti(SO4)2 solution,
but increased with the increasing of the flow rate of NH4HCO3 solution.

Key words: micro-mixing-precipitation, TiO2, ultra-fine

中图分类号: