高级检索
无机材料学报

无机材料学报 >

2010 , Vol. 25 >Issue 3: 235 - 241

DOI: https://doi.org/10.3724/SP.J.1077.2010.00235

研究论文

高分散纳米晶Li4Ti5O12电极材料的制备及电化学性能的研究

  • 王 瑾 ,
  • 成雪莲 ,
  • 王子港 ,
  • 杨 晖
展开
  • 南京工业大学 材料科学与工程学院, 南京 210009

收稿日期: 2009-06-25

  修回日期: 2009-08-17

  网络出版日期: 2010-03-20

收起

Synthesis and Electrochemical Properties of Highly Dispersed Li4Ti5O12
Nanocrystalline as Anode Material for Lithium Secondary Batteries

  • WANG Jin ,
  • CHENG Xue-Lian ,
  • WANG Zi-Gang ,
  • YANG Hui
Expand
  • College of Materials Science and Engineering, Nanjing University of Technology, Nanjing 210009, China

Received date: 2009-06-25

  Revised date: 2009-08-17

  Online published: 2010-03-20

Fold

摘要

以月桂酸为分散剂, 采用无水溶胶凝胶法合成了高分散的Li4Ti5O12纳米晶. 采用XRD、SEM、TGDSC、激光粒度分析仪、交流阻抗以及恒流充放电测试, 对材料的形貌、结构和电化学性能进行表征. 结果表明, 煅烧温度对Li4Ti5O12的结晶度、微观形貌及其电化学性能有显著的影响. 800℃下热处理10h后的产物, 颗粒尺寸细小均匀, 约在120~275nm之间, 显示出优异的电化学性能. 在0.5和1C倍率下, 首次放电比容量分别可达174.7和163.3mAh/g, 经过50次放电循环后, 放电容量循环性能优异. 研究表明该高分散纳米颗粒的合成方法是适合制备高电化学性能的Li4Ti5O12材料的工艺方法.

关键词： Li4Ti5O12; 纳米晶; 表面活性剂; 放电容量

本文引用格式

王 瑾 , 成雪莲 , 王子港 , 杨 晖 . 高分散纳米晶Li4Ti5O12电极材料的制备及电化学性能的研究[J]. 无机材料学报, 2010 , 25(3) : 235 -241 . DOI: 10.3724/SP.J.1077.2010.00235

Abstract

Nano-sized Li4Ti5O12 powder with high dispersivity was prepared by a novel solgel route using lauric acid as surfactant. The crystal structure, microstructure and the electrochemical properties of samples were characterized by XRD, FESEM, TGDSC, laser particle size analysis, A.C. impedance and galvanostatically chargedischarge experiments. The results demonstrated that the crystallization, microstructure and electrochemical properties were influenced significantly by heattreatment temperature. Li4Ti5O12 powders calcined at 800℃ for 10h were comprised of crystallites with the particle size in the range of 120-275nm, revealing high dispersivity almost without any agglomerates, and exhibiting an excellent electrochemical performance. Its discharge capacities at 0.5C and 1C rates were 174.7mAh/g and 163.3mAh/g, respectively. After 50 cycles, fairly stable cycling performance was achieved without obvious capacity fading. Electrochemical impedance spectroscopy tests demonstrated that the surface reaction kinetics of Li4Ti5O12 was improved significantly from the state of the complete charge to the state of the complete discharge. The charge and discharge results of samples demonstrated that the route to synthesis highly dispersed nanocrystalline was appropriate for preparing Li4Ti5O12 with high electrochemical performance.

Key words： Li4Ti5O12; nanocrystalline; surfactant; discharge capacity

参考文献

［1］Ohzuku T, Ueda A, Yamamoto N. Zerostrain insertion materials of Li［Li 1/3 Ti 5/3］O4 for rechargeable lithium cells. J. Electrochem. Soc., 1995,142(5): 1431-1435.

［2］Mukai K, Ariyoshi K, Ohzuku T. Comparative study of Li［CrTi］O4, Li［Li 1/3 Ti 5/3］O4 and Li1/2Fe1/2［Li 1/2 Fe 1/2 Ti］O4 in nonaqueous lithium cells. J. Power Sources, 2005, 146(1/2): 213-216.

［3］Zaghib K, Simoneau M, Armand M, et al. Electrochemical study of Li4Ti5O12 as negative electrode for Li-ion polymer rechargeable batteries. J. Power Sources, 1999, 81-82: 300-305.

［4］Ariyoshi K, Yamato R, Ohzuku T. Zero-strain insertion mechanism of Li［Li 1/3 Ti 5/3］O for advanced lithiumion (shuttlecock) batteries. Electrochim. Acta, 2005, 51(6): 1125-1129.

［5］Ge H, Li N, Li D Y, et al. Study on the effect of Li doping in spinel Li 4+x Ti 5-x O12 (0≤x≤2) materials for lithium-ion batteries. Electrochem. Commun., 2008, 10(7): 1031-1034.

［6］Huang S H, Wen Z Y, Zhu X J, et al. Effects of dopant on the electrochemical performance of Li4Ti5O12 as electrode material for lithium ion batteries. J. Power Sources, 2007, 165(1): 408-412.

［7］Wolfenstine J, Allen J L. Electrical conductivity and charge compensation in Ta doped Li4Ti5O12.J. Power Sources, 2008, 180(1): 582-585.

［8］Robertson A D, Trevino L, Tukamoto H, et al. New inorganic spinel oxides for use as negative electrode materials in future lithium-ion batteries. J. Power Sources, 1999, 81-82: 352-357.

［9］Sun Y K, Jung D J, Lee Y S, et al. Synthesis and electrochemical characterization of spinel Li［Li (1-x)/3 CrxTi (5-2x) /3］O4 anode materials. J. Power Sources, 2004, 125(2): 242-245.

［10］苏岳峰, 吴 峰, 臧 戈, 等(SU YueFeng, et al). 多孔炭模板法制备Li4Ti5O12及其嵌锂行为. 物理化学学报(Acta Phys.Chim. Sin.), 2008, 24(6): 1002-1006.

［11］Guefri A, Charest P, Kinoshita K, et al. Nano electronically conductive titaniumspinel as lithium ion storage negative electrode. J. Power Sources, 2004,126(1/2): 163-168.

［12］Cheng L, Li X L, Liu H J, et al. Carboncoated Li4Ti5O12 as a high rate electrode material for Li-ion intercalation. J. Electrochem. Soc., 2007, 154(7): A692-A697.

［13］Wang G J, Gao J, Fu L J, et al. Preparation and characteristic of carboncoated Li4Ti5O12 anode material. J. Power Sources, 2007, 174(2): 1109-1112.

［14］Huang J J, Jiang Z Y. The preparation and characterization of Li4Ti5O12/carbon nanotubes for lithium ion battery. Electrochim. Acta, 2008, 53(26): 7756-7759.

［15］Liu H, Feng Y, Wang K, et al. Synthesis and electrochemical properties of Li4Ti5O12/C composite by the PVB rheological phase method. J. Phys. Chem. Solids, 2008, 69(8): 2037-2040.

［16］Jiang C H, Ichihara M, Honma I, et al. Effect of particle dispersion on high rate performance of nanosized Li4Ti5O12 anode. Electrochim. Acta, 2007, 52(23): 6470-6475.

［17］Jiang C H, Hosono E J, Ichihara M, et al. Synthesis of nanocrystalline Li4Ti5O12 by chemical lithiation of anatase nanocrystals and postannealing. J. Electrochem. Soc., 2008, 155(8): A553-A556.

［18］Choi D, Kumta P N. Surfactant based sol-gel approach to nanostructured LiFePO4 for high rate Li-ion batteries. J. Power Sources, 2007, 163(1/2): 1064-1069.

［19］Bach S, PereiraRamos J P, Baffier N. Electrochemical properties of solgel Li 4/3 Ti 5/3 O4. J. Power Sources, 1999, 81-82: 273-276.

［20］Fu L J, Liu H, Li C, et al. Electrode materials for lithium secondary batteries prepared by sol-gel methods. Prog. Mater. Sci., 2005, 50(7): 881928.

［21］Xie D, Pan W. Study on BaBi4Ti4O15 nanoscaled powders prepared by sol-gel method. Mater. Lett., 2003, 57(19): 2970-2974.

［22］赵国玺. 表面活性剂物理化学. 北京: 北京大学出版社, 1984: 3663.

［23］Robertson A D, Tukamoto H, Irvine J T S. Li1+xFe13xTi1+2xO4 (0≤x≤0.33) based spinel: possible negative electrode materials for future Liion batteries. J. Electrochem. Soc., 1999, 146(11): 39583962.

［24］苏岳峰, 吴 峰, 陈朝峰(SU YueFeng, et al). 纳米微晶TiO2合成Li4Ti5O12及其嵌锂行为. 物理化学学报(Acta PhysChim. Sin.), 2004, 20(7): 707711.

［25］Kim D H, Ahn Y S, Kim J. Polyolmediated synthesis of Li4Ti5O12 nanoparticle and its electrochemical properties. Electrochem. Commun., 2005, 7(12): 13401344.

［26］Yuan T, Cai R, Wang K, et al. Combustion synthesis of highperformance Li4Ti5O12 for secondary Liion battery. Ceram. Int., 2009, 35(5): 17571768.

［27］Plett G L. Extended Kalman filtering for battery management systems of LiPBbased HEV battery packs: Part 2. Modeling and identification. J. Power Sources, 2004, 134(2): 277292.

［28］Wolfenstine J, Lee U, Allen J L. Electrical conductivity and ratecapability of Li4Ti5O12 as a function of heattreatment atmosphere. J. Power Sources, 2006, 154(1): 287289.

Options
文章导航

/

〈 〉