高级检索
无机材料学报

无机材料学报 >

2009 , Vol. 24 >Issue 1: 171 - 174

DOI: https://doi.org/10.3724/SP.J.1077.2009.00171

研究论文

MgAlZnFeCe类水滑石水热合成、表征及其FCC硫转移性能的研究

  • 赵月昌 ,
  • 刘 玲 ,
  • 程文萍 ,
  • 吴海虹 ,
  • 杨建国 ,
  • 何鸣元
展开
  • 1．华东师范大学 化学系，上海市绿色化学与化工过程绿色化重点实验室，上海 200062; 2. Energy Institute, College of Earth and Mineral Sciences, Pennsylvania State University, University Park, PA 16802, USA

收稿日期: 2008-03-11

  修回日期: 2008-04-30

  网络出版日期: 2009-01-20

收起

Hydrothermal Synthesis of MgAlZnFeCe Hydrotalcite-like Precursors and Their Complex Oxides for Application in FCC De-SOx

  • ZHAO Yue-Chang ,
  • LIU Ling ,
  • CHENG Wen-Ping ,
  • WU Hai-Hong ,
  • YANG Jian-Guo ,
  • HE Ming-Yuan
Expand
  • 1. Shanghai Key Laboratory of Green Chemistry and Chemical Process, Department of Chemistry, East China Normal University, Shanghai 200062, China； 2. Energy Institute, College of Earth and Mineral Sciences, Pennsylvania State University, University Park, PA 16802, USA

Received date: 2008-03-11

  Revised date: 2008-04-30

  Online published: 2009-01-20

Fold

摘要

分别以MgO为镁源，拟薄水铝石为铝源，以Zn、Fe、Ce的氯化盐为助剂，水热法合成了MgAlZnFeCe类水滑石前驱体，经过700℃焙烧6h后，制得新型FCC硫转移剂MgAlZnFeCe复合氧化物.运用XRD、TG-DTA等对硫转移剂及其前驱体的结构和物化性能进行了表征；在模拟FCC反应再生条件下，采用改装的WRP-3热重天平评价了硫转移剂的氧化吸硫和还原脱硫的性能.结果表明，采用水热法合成的前驱体材料具有典型的类水滑石结构，但MgO不能完全进入水滑石相，以Mg(OH)2的形式存在；类水滑石材料经过焙烧后得到复合氧化物MgAlZnFeCe-LDOs，在FCC再生烟气硫转移中具有良好的饱和吸附硫容量和氧化吸硫速率，10min可达到1.16g/g的饱和吸附能力，同时具有较强的还原脱硫能力.

关键词： 硫转移剂; 类水滑石; 水热合成; 氧化吸硫; 还原脱附

本文引用格式

赵月昌 , 刘 玲 , 程文萍 , 吴海虹 , 杨建国 , 何鸣元 . MgAlZnFeCe类水滑石水热合成、表征及其FCC硫转移性能的研究[J]. 无机材料学报, 2009 , 24(1) : 171 -174 . DOI: 10.3724/SP.J.1077.2009.00171

Abstract

MgAlZnFeCe hydrotalcite-like precursors were prepared by a hydrothermal method using MgO as magnesium resource and pseudoboehmite as aluminum resource, and using metal chlorides of Zn,Fe and Ce as catalytic additives. MgAlZnFeCe complex oxides were prepared by decomposition of MgAlZnFeCe hydrotalcite-like precursors at 700℃ for 6h, which were used for the removal of SOx from FCC flue gas. XRD, TG-DTA analysis show that hydrotalcite-like compound is the major component while the minor phase is Mg(OH)2 as the impure phase. The results of SOx adsorption-reduction test show that the novel catalyst MgAlZnFeCe-LDO reaches 1.16g/g of total saturation adsorption capacity in 10min in the condition similar to that of a typical FCC, which achieves high oxidative adsorption rate, short saturation time, and large reductive capacity. 

Key words： sulfur transfer catalyst; hydrotalcite-like compound; hydrothermal method; SOx oxidative adsorption; reductive desorption

参考文献

1］Jae L S, Jun H K, Jung S Y, et al. Ind. Eng. Chem. Res., 2005, 44(26): 9973-9978.
［2］Wang J A, Chen L F, Li C L. J. Mol. Catal. A: Chemical, 1999, 139(2): 315-323.
［3］Cheng W P, Yu X Y, Wang W J, et al. Catalysis Communications, 2008, 9 (6) ：1505-1509.
［4］Cantú M, López-Salinas E, Valente J S. Environ. Sci. Technol., 2005, 39 (24): 9715-9720.
［5］Armor J N, Braymer T A, Farris T S, et al. Appl. Catal. B, 1996, 7(3-4): 397-406.
［6］Pérez-Ramírez J, Overeijnder J, Kapteijn F, et al. Appl. Catal. B, 1999, 23(1): 59-72.
［7］温 斌,何鸣元,宋家庆,等.环境化学,2000,19 (3): 197-203.
［8］朱仁发,李承烈.化工进展,2000,19(3):22-29.
［9］任庆利,罗 强,陈寿田,等.西安交通大学学报,2005,39(2): 187-190.
［10］Xu Z P, Lu G Q. Chem. Mater., 2005, 17(5): 1055-1062.
［11］温 斌,何鸣元,宋家庆,等.催化学报,21(1): 31-34.
［12］Cantú M, López-Salinas E, Valente J S, et al. Environ. Sci. Technol., 2005, 39(24): 9715-9720.
［13］Greenwell H C, Holliman P J, Jones W, et al. Catal. Today, 2006, 114 (4): 397-402.
［14］程文萍,王雯娟,刘 玲,等.催化学报, 2007,12(28): 1112-1116.
［15］Bhattacharyya A A, Woltermann G M, Yoo J S, et al. Ind.Eng.Chem.Res., 1988, 27(8): 1356-1360.
Options
文章导航

/

〈 〉